12 volt 40 amp Battery Box
Lithium Phosphate Battery Pack BP2570 Battery in 2712 Explorer Case
OPERATING INSTRUCTIONS
FEATURES
· Lightweight - Approximately ¼ of the weight
of equivalent capacity Sealed Lead Acid batteries
· Flat discharge curve - Constant power for longer
· No memory effect
· Short circuit protected
· Fuel Gauge - Displays battery power status
· Protected against:
· OVERCHARGE
· OVER TEMPERATURE
· OVER CURRENT
· DEEP DISCHARGE
· SHORT CIRCUIT
PRECAUTIONS IN USE
· DO NOT dispose of in normal household refuse
· DO NOT attempt to dismantle the battery pack in any way
· DO NOT short circuit your battery pack - it could overheat and cause
fire or explosion
· ONLY use the charger supplied with battery pack
· Your battery pack will need to be charged fully before use. If storing
your battery pack, store in a charged state. Recharge every 6 months
· It is recommended to recharge the battery pack within 12 hours if fully
discharged
· Excess heat will degrade the battery pack rapidly. Always store your
battery pack in a cool dry place. DO NOT leave for long periods in the sun or
in a hot vehicle
· DO NOT immerse your battery pack in water
IMPORTANT CHARGER INFORMATION
· Only use the charger supplied with the battery pack.
· Do not use this charger for any other purpose. It has been designed
to be used with this battery pack only.
RECHARGING THE BATTERY PACK
1. Plug the charger into A.C. mains - the LED light will
glow GREEN.
2. Plug the charger plug firmly into the battery pack - the LED light will change
to RED to indicate charging.
3. When the LED light changes back to GREEN then the battery pack is fully charged.
4. Disconnect the charger from the battery pack and from the A.C. mains.
5. DO NOT leave the charger connected to the battery for long periods after
the battery is charged.
TRANSPORTATION
There are many regulations regarding the transportation of lithium batteries. Please consult the IATA, your airline, local carrier or www.tracerpower.com for more information.
INST080 - Issue:1 - Mar 2012 - Page 1 of 2
SPECIAL LIFEPO4 BATTERY PACKS + CHARGERS - OPERATING INSTRUCTIONS (Cont….)
BATTERY PACK SPECIFICATIONS:
BATTERY PACK: BP2570 BP2572 BP2574 BP2576 BP2578 BP2580
Voltage 12v 12v 12v 12v 24v 24v
Capacity 40Ah 60Ah 80Ah 100Ah 8Ah 20Ah
Dimensions (mm) (Note1) 210x145x90 ? ? ? 165x125x110 (Note2) 215x150x100
Weight (grams) (Note1) 4600 ? ? ? 2080 (Note2) 4600
Max continuous output current 20A 20A 20A 20A 8A 20A
Charger 12v 4A 12v 4A 12v 4A 12v 4A 24v 2A 24v 2A
Typical charging time 10 - 15 hours 15 - 22 hours 20 - 30 hours 25 - 37 hours
4 - 6 hours 10 - 15 hours
Note1: Dimensions and weight are for the basic battery block without case
Note2: This battery is supplied in an orange/black case. Dimensions & weight
are including the case.
BATTERY "FUEL GAUGE" OPERATION (not fitted):
IMPORTANT: To stop using the battery when the LED go's off
as the battery will switch it's self off and it could happen when recording
WARRANTY
Your new battery has a 24 month warranty (from the date of
purchase) against premature failure due to defects in materials and/or workmanship,
subject to the following conditions:
· The warranty does not cover failure due to damage caused by abuse*
· The warranty does not cover failure from excessive wear and tear even
within the warranty period
· A till or computer generated proof of purchase must accompany your
claim
· The warranty is limited to the original owner and is not transferable
· Should any original defect appear, please log your warranty claim with
your retailer or at www.tracerpower.com
The warranty is void if:
· The serial number is removed from the product
· The battery or connection system has been modified in any way
· The battery has been left in a discharged state
This warranty is limited to the original purchaser and is in addition to your statutory rights
*Charge your battery directly after each use. Leaving your
battery in a discharged state will seriously and permanently damage its
performance. Please note we cannot uphold warranty claims in these circumstances.
12 Volt 4 Amp Charger for above is £39.00
To buy this item please telephone: Mike Harris 01932 241 948, or click the contact button for more options.